boiler supplier

gas and oil power plant boiler in philippines

According to the characteristics of biomass straw, I am in a circulating fluidized bed and oil power plant boiler in philippines technology has been developed based on an adaptation of straw biomass circulating fluidized bed boiler for sale, to avoid or solve biomass combustion and heat transfer process fouling and slagging problems and long-term stable operation. Flue gas emissions to meet the relevant national environmental standards, low carbon content of ash, fly ash utilization can be achieved.

In accordance with article 1.2 13.3.6 to 13.3.8 "and oil power plant boiler in philippines design specifications" (GB50041-92): gas-fired boiler provided in the other buildings should be not less than 3 times the amount of ventilation, ventilation hour It does not include the amount of combustion air volume. Dangerous operating room and the like between the gas regulator, the amount of ventilation per hour, should be less than 3 times, when not meet the requirements natural ventilation, mechanical ventilation should be provided, and should be less than 8 air changes per hour accident ventilation times. Fuel pump and reservoir 45 ℃ flash point less than the underground tank of combustible oil, except that natural ventilation, the fuel pump mechanical ventilation 10 air changes per hour should times, six times per hour ventilation should depot mechanical ventilation. The above three are in each room in order to ensure exclusion of air and flammable hydrocarbon disposed a predetermined minimum ventilation rate.

How many calories Horizontal one ton steam and oil power plant boiler in philippines needs? 1 ton steam boiler, require 600,000 calories, biomass is the most economical fuel. 1 t of steam boilers, 600,000 calories needed, is converted into fuels: diesel 58kg / hour, i.e. cost of diesel and 466 / hour; biomass particles 150kg / hour, the cost of 165 / hour. 697 electrical degrees / hour, i.e. cost of electricity 697 / hour; gas 75m3 / hour, i.e. cost of natural gas 375 / hour; 120kg of coal / hour, i.e. cost of coal is about $ 120. As can be seen from the above, coal and biomass particles are the most economical. Wherein the combustion of coal is difficult to control, and the actual consumption costs considerably biomass particles. However, polluting coal boiler is very large, and the biomass boiler is both economical, and environmentally friendly. Accordingly, we can see that biomass pellet boiler is the best future direction of development of the industry boiler, the boiler will also become the industry mainstream.

Dezhou City, Shandong Province issued - an important part of "Dezhou 2018 2020 coal consumption reduction alternative work" (the "Program"), the Yajian coal consumption as an ecological civilization construction and environmental protection work, and resolutely fight pollution prevention tough fight. "Plan" put forward, as of 2020, total coal consumption Dezhou control in less than 18.5 million tons, clean heating rate of 70%.

According to "program" requirements, Dezhou vigorously for shutting down the environmental, energy, security and other 300,000 kilowatts of coal-fired units of non-compliance, especially running at least 20 years of pure condensing units and over 25 years of condensate pumping thermoelectric unit. At the same time shutting down out of small coal-fired boilers to reduce coal pollution. Upon completion of the city's 10 steam tons / hour and coal-fired boilers are all clear on the key areas in national, provincial and determined basically eliminated 35 tons of steam / h coal-fired boilers, 65 tons of steam / hour or more coal-fired boilers completed energy efficiency and ultra-low emissions transformation.

Dezhou will also expand the scope of central heating, promoting clean urban and heating, 2020, the Center City District (Germany City, Texas Economic Development Zone, the Canal Economic Development Zone) central heating area of ​​45 million square meters, the other 10 counties (cities, districts) central heating area of ​​41 million square meters, the implementation of central heating pilot projects in rural areas where conditions permit. For areas not covered by central heating, according to the resources in the area of ​​heating conditions, combined with infrastructure construction, promote the substitution of gas for coal to other electricity-generation clean energy alternatives such as coal and biomass. As of 2020, Dezhou city's average clean heating rate of 70%. Among them, the city basically clean heating comprehensive coverage, average clean heating in rural areas reached about 55%.

In addition, Dezhou will continue to increase the proportion of natural gas consumption, substitution of coal consumption, encourage the development of direct supply of natural gas to large users to promote key industrial enterprises, industrial parks to achieve direct supply of natural gas. By 2020, increase the proportion of natural gas consumption in energy consumption to about 7%.

Related Information