boiler supplier

liquid petroleum gas hot water boiler

Combustion gas treatment unit and a fault, gas boiler burner ignition misfire rod reasons: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Measures following five: Clear, renewal, adjust the distance, change and switching transformer. Second, gas boiler, but spark ignition rods misfire reasons: 1, the cyclone disc space ventilation is blocked carbon, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Measures are: Clear; first wash, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel); Check tubing and oil filters, insulation equipment ; remove peripheral screw pump, carefully remove the cover inside out oil network, with immersion oil; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing instability reasons: 1, the air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, fuel oil boiler water. Action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; approximately set to about 50 deg.] C; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Processing methods: ① the oil line check valve is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.

Coal-fired steam boiler scale can cause harm and failure scale is the first coal-fired steam boilers, coal-fired steam boiler is the main cause of the accident, the danger main problems: wasting a lot of fuel: Because the thermal conductivity of the scale of only a few steel one tenth, so that the heating surface when the fouling of heat transfer will hindered, in order to maintain a coal-fired steam output, it is necessary to increase the temperature of the side of the fire, so that the external radiation and flue gas heat loss. Now can be used efficient and environmentally non-corrosive cleaning agent fired steam cleaning, expose the metal tube so that the device primaries, and to reduce biological fouling of algae because silt impact. While the peeling effect of iron on the iron oxide and ethylene, prolong the service life of coal-fired steam boilers, to reduce energy consumption and improve productivity. Fired steam after a long run, the inevitable emergence of scale, the problem of corrosion, scale coal-fired steam boiler formation is mainly due to the water with hardness components, high temperature, high pressure after continuously concentrated by evaporation, the coal-fired steam furnace with a series of physical, chemical, and finally heating surface to form a hard, dense scale, resulting in reduced heat transfer and the effect of corrosion under the scale factors, leads to a reduction endothermic coal-fired steam boiler waterwall furnace, burning coal steam boiler furnace exit temperature increases, the increase in the loss of coal-fired steam boilers. After scaling while reducing the heat transfer within the water wall, water wall tube wall temperature may lead to increased water wall lead to burst pipes, affect the safe operation of coal-fired steam boilers.

When electric power boilers tips based on electricity energy by electromagnetic induction heating or resistance heating, the hot water or organic heat medium (steam gas) heated to a certain parameters (temperature, pressure) of the boiler through the heat exchanger portion, to output having a nominal outer working fluid a thermal mechanical apparatus. Definition of boiler: boiler, refers to the use of various fuels, electrical or other energy, the contained liquid will be heated to a certain parameter, and the device sealed bearing certain pressure, the volume of which is defined in a range equal to or greater than the pressure of the steam 30L boilers; the outlet pressure is greater than or equal to 0.1MPa (gauge pressure), and the rated power greater than or equal to 0.1MW pressure liquid petroleum hot water boiler, electric boiler organic heat carrier. In other words, no matter what fuel to use, the scope of its provisions are the same, just different fuel source.

July 26, 2016, Beijing, China Everbright Paper Co., Ltd. and the company signed a "split 6 tons of steam condensing gas steam boiler contract" by the company responsible for the WNS6-1.25-YQ split condensing gas boiler steam to all production, installation and commissioning work. The product is the use of condensing technology, effective emission of harmful substances SOx, NOx, COx, is industrial boilers efficient and environmentally friendly solutions.

Related Information